|
2024-05-31 |
|
|
20 quart whisk has a broken wire. Can it be cut? It is on the desk in the production office with a red tag. Thanks! |
|
|
removed wire |
|
2024-05-29 |
|
|
Please replace table wheels with quality locking mechanism wheels. Same as the "re-run bench" those work great. |
|
|
replaced wheels with "quality locking mechanism" wheels |
|
2024-05-28 |
Other |
|
we have several wooden tables that need sanded because there are dings in them. One specific spot that needs attention is by where the sheeter slide goes onto the table. It is right on the corner and splintering. |
|
|
repaired |
|
2024-05-27 |
Other |
replace baseboard where the floor hits the ceramic tile in the bread bagel area |
common area wall is molding baseboard is off. by where the old door area is. Floor might need some replacing nad or the molding there, it molds and there was bugs there |
|
|
Replaced wall base |
|
2024-05-27 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-05-27 |
Other |
Baking rack wheels are no go |
Wheels are messed up and it’s very difficult to push/pull |
|
|
could not verify. tom may have completed |
|
2024-05-26 |
|
|
Drain condensation from air compressor tanks of both stationary air compressors |
|
|
complete |
|
2024-05-23 |
Other |
Equipment |
I’d suggest a full swap on all the wheels and casters but the wheels don’t rotate well with product on the shelves |
|
|
replaced wheel and lubed others |
|
2024-05-23 |
Freezer |
|
the cake freezer motor is shaking the walls, and now the consultation glass door. I am not sure if we can do anything, but I do not think it should be shaking like it is. |
|
|
defrosted |
|
2024-05-22 |
HVAC |
|
Check filters and replace when necessary. Check P traps for condensation and drain as necessary. Check condensor coils. WEEKLY DURING SPRING SUMMER, MONTHLY AFTER FIRST FREEZE |
|
|
Tom cleaned today |
|
2024-05-22 |
Other |
Rack washer |
Rack burner not firing. Video attached |
|
|
repaired, ordering new gas regulator |
|
2024-05-20 |
|
|
Locker room exterior door does not fully shut after opened.
Not sure if this is a pressure issue, mechanism issue, or if it is only an early morning issue.
Our building is not secure currently. |
|
|
repaired |
|
2024-05-20 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-05-20 |
|
|
Two hand sifters not turning. Red tagged on utensils shelf. |
|
|
repaired |
|
2024-05-19 |
Other |
delivery plastic wrap holder broken |
Plastic film holder is broken and/or missing pieces. Gave to Ben. Not sure if we can order missing parts and or fabricate something. Or toss and order new? |
|
|
repaired |
|
2024-05-19 |
|
|
Rolling pin handle split. Not sure if it can be repaired. Wrote work order just in case. |
|
|
repaired |
|
2024-05-17 |
Other |
blade for bread slicer found on floor by bread slicer in delivery by sink |
I put the blade in Jaison R desk with a note. |
|
|
repaired |
|
2024-05-17 |
Freezer |
|
Freezer fans have not kicked on since I've been here at 6:15 am |
|
|
connecter for power of fans disconnected. all good |
|
2024-05-16 |
|
|
When using the drum for the smalls, the weights are not the same. The cookies closest to the wall are about right but the cookies closest to the person operating are consistently underweight |
|
|
we need video or to see it in action to determine probable cause |
|
2024-05-14 |
Other |
Wheels |
We have a baking rack in the mill room with a red tag that has bad wheels.
For some reason the original WO was closed out. The rack is still in the mill room with a red tag and has bad wheels. |
|
|
repaired |
|
2024-05-13 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-05-13 |
|
|
Re-spray the flat sheet trays green. Can this be done today? We don't have many on the floor so 90% could be done in one go and then be ready for use on Tuesday |
|
|
complete |
|
2024-05-13 |
Other |
Wheels |
We have a baking rack in the mill room with a red tag that has bad wheels. |
|
|
repaired |
|
2024-05-12 |
Oven |
|
On 12 door Oven; Blow out burners, clean |
|
|
blew out burner |
|
2024-05-12 |
|
|
De-grease, and re-grease bowl lifter lift pole and chain. |
|
|
greased |
|
2024-05-12 |
Other |
paint/seal or replace rack in bread cooler |
First rack on right in Bread walk in has extensive rust. Please paint and seal with food grade epoxy pain or replace shelves. |
|
|
replaced |
|
2024-05-12 |
Other |
Torch top |
The torch top lock was stuck in the lock position. We were able to get it unstuck to use it, but it will easily get stuck again. Now the torch will not light at all. Red tagged and in the production managers office on the pastry desk. Thanks! |
|
|
replaced |
|
2024-05-11 |
|
|
There is a plastic cart where the plastic piping that makes of the legs is cracking |
|
|
replaced legs |
|
2024-05-11 |
|
|
broken soup lid |
|
|
repaired |
|
2024-05-10 |
Other |
grease bearings |
grease all 3 inserts on each mill |
|
|
lubed |
|
2024-05-09 |
Other |
Floor scrubber batteries |
Check battery cell levels and flush out cleaner dilution valve |
|
|
Batteries are at normal level |
|
2024-05-09 |
Oven |
|
12-door oven has an issue with the left hand side troughs that dont allow them to drain, consequently the troughs spill over on to the decks when steaming. this affects all of the decks. |
|
|
replaced button that was broken and checked drainage, opened bottom drain hole |
|
2024-05-09 |
|
|
Reach in cooler is making a rattling noise near the fan! |
|
|
normal, water hitting fan underneath fan |
|
2024-05-07 |
Other |
dish table in bread mix area on tile has messed up wheel |
it is red tagged |
|
|
replaced wheels |
|
2024-05-06 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
no water |
|
2024-05-03 |
|
|
Large cookies are coming out of the machine oval shaped instead of circular |
|
|
tightened wire |
|
2024-05-02 |
|
|
Can we get a second barrier installed on the right side of the end metal mixer table (the metal one closest to the cake department?) We are now storing our metal mixer hooks on the side and need to avoid potential metal shavings |
|
|
installed edge trim |
|
2024-05-01 |
Other |
grease bearings |
grease all 3 inserts on each mill |
|
|
Greased |
|
2024-05-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
checked all gas appliances, no leaks |
|
2024-05-01 |
Plumbing |
|
The warehouse toilet won't stop running. |
|
|
duplicate |
|
2024-05-01 |
Freezer |
|
The cake freezer fans are still making a really loud noise. |
|
|
cleared the ice |
|
2024-05-01 |
Plumbing |
|
The cake sink is still not getting warm and not a very heavy stream. |
|
|
adjusted mixing valve, cleared debris from aerator |
|
2024-05-01 |
|
|
The pedal for the cookie machine is needing increasing amounts of pressure to work... |
|
|
freed up foot pedal. It now works normally. In order for the manual mode to work with foot pedal, you must press green button once. |
|
2024-05-01 |
|
|
The plastic marker we use for our cinnamon rolls cracked in half :( Can we have another one made, please? |
|
|
two markers are in the process of being made |
|
2024-05-01 |
Plumbing |
|
The grease trap leaked a LOT of water into the classroom when the first sink was emptied tonight |
|
|
emptied trap |
|
2024-04-30 |
HVAC |
|
Ac vent is dripping condensation |
|
|
could not find anything leaking |
|
2024-04-29 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
n/a |
|
2024-04-29 |
Freezer |
|
The cake freezer fans need cleaning, they are making the loud noise again. |
|
|
defrosed |
|
2024-04-27 |
Other |
replace wheel in egg room hallway its on the rack against dish room wall in hallway. |
it is red tagged |
|
|
replaced wheels |
|
2024-04-27 |
Other |
replace wheel egg room by green stairs |
it is red tagged |
|
|
replaced wheels |
