|
2024-03-23 |
|
|
Metal pitcher has handle falling off |
|
|
repaired |
|
2024-03-22 |
Other |
please check proofer, big puddle in there today thank you |
|
|
|
cleaned out tubing |
|
2024-03-22 |
Other |
Break room floor- in front of the fridge. |
There is a very large, deep hole in the floor. It is difficult to move the chair without it getting stuck. |
|
|
repaired and will tile later |
|
2024-03-22 |
Other |
2 wheels on wire rack that are red tagged, in pacakging |
The wire rack between offices and sticker room; |
|
|
repaired |
|
2024-03-22 |
HVAC |
|
Check filters and replace when necessary. Check P traps for condensation and drain as necessary. Check condensor coils. WEEKLY DURING SPRING SUMMER, MONTHLY AFTER FIRST FREEZE |
|
|
replaced all roof filters and vacuumed fins on all roof units |
|
2024-03-21 |
Other |
two wheels on the non allergen moulder in bread |
red tagged, very difficult to move to clean floor underneath |
|
|
replaced wheels |
|
2024-03-21 |
Other |
one wheel on cart by 9 door deck oven |
red tagged, and needs replacing |
|
|
could not find |
|
2024-03-20 |
Mixer |
|
I know Tom was looking into another grease for the mixer, but can we please get it cleaned and regreased so we can use it in the meantime? Thank you so much! I do aplogize |
|
|
replaced transmission oil seal and replaced all grease inside machine. |
|
2024-03-20 |
Electrical |
|
Please install new speaker/horn above Pastry mixers for Emergency Alerts. |
|
|
installed |
|
2024-03-18 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
complete |
|
2024-03-17 |
Other |
pastry freezer ramp |
Can we please have some of the sharp edges on the pastry ramp filed down? The areas I am referring to are on the two pieces that jut out, so there are 4 sharp edges total, two on each side.
I moved the ramp on the wall next to the cookie machine for the time being so it doesn't fall on someone.
Thanks! |
|
|
made safer and found new place. |
|
2024-03-16 |
|
|
One of our water sprayers ain't spraying. There doesn't seem to be any gathering pressure when you're pumping it |
|
|
repaired |
|
2024-03-15 |
Other |
|
the top hinge on the far right side in our grey cabinet below the display cakes needs a new screw. It came off the hinge. Thank you! |
|
|
repaired |
|
2024-03-12 |
Other |
chinois strainer |
The chinois strainer is in two pieces. Perhaps it can be repaired (maybe welded) If not, we can order a new one.
Red tagged and in the production managers office on the pastry desk. |
|
|
Please order |
|
2024-03-12 |
Oven |
|
On 12 door Oven; Blow out burners, clean |
|
|
blown out |
|
2024-03-12 |
|
|
De-grease, and re-grease bowl lifter lift pole and chain. |
|
|
greased |
|
2024-03-12 |
Oven |
|
On 12 door Oven; Blow out burners, clean |
|
|
blown out |
|
2024-03-12 |
|
|
De-grease, and re-grease bowl lifter lift pole and chain. |
|
|
greased |
|
2024-03-12 |
Other |
Outside signage removal |
Please remove the sign posts in the front of the building that used to have info on them regarding the parking spaces and pick up orders. |
|
|
removed |
|
2024-03-11 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
N/a |
|
2024-03-09 |
Mixer |
|
Old large pav mix fork falls quite easily. |
|
|
repaired |
|
2024-03-09 |
|
|
Replace table wheels with better locking mechanism. Legs tagged with yellow tape. |
|
|
complete |
|
2024-03-09 |
Other |
Floor scrubber batteries |
Check battery cell levels and flush out cleaner dilution valve |
|
|
Filled |
|
2024-03-08 |
|
|
Dish drying rack coming off wall, request new shelf or to be more secure on wall. |
|
|
resecured |
|
2024-03-06 |
Other |
Pastry sheeter against the silver freezer wall will not stay up when lifted up to move. |
|
|
|
could not verify issue |
|
2024-03-06 |
|
|
the problem michael wrote about our slicer has gotten worse/louder and extremely uncomfortable to hear. the back metal plate is scraping the moving parts on the side, near the blades. |
|
|
repaired |
|
2024-03-06 |
Other |
Trim Hose |
The air compressor hose has a hole in it pretty near the nozzle. Could you please remove the damaged section?
Thank you |
|
|
Repaired |
|
2024-03-06 |
Other |
Please cut all top poles of all racks in the bread walk-in |
So they can fit in the LVO to get cleaned |
|
|
DONE |
|
2024-03-05 |
Other |
Wheels on long wire racks in Scaling, both of them, need replacing |
Mulputle wheels are bad, unable to move well, not safe. |
|
|
replaced wheels on 1/2 racks. ordered more wheels |
|
2024-03-05 |
Other |
Floor machine squeegee is extremly stopping draggin the machine |
It will work fine for a short bit then it does not want to go, and it is not the auto go it is something with the sqeegee assembly. Please check |
Recharged battery |
|
|
|
2024-03-05 |
Other |
Wheels on short sheets in bread are messed up, one is extremly hard to even think of moving. |
|
|
|
please clarify issue thanks |
|
2024-03-04 |
Mixer |
|
Please bolt Phebus mixer to floor. It slides around when I take bowl on and off mixer, as well as during the mixing. |
|
|
It is in the same spot when I installed it. Directions call for it to not be bolted. |
|
2024-03-04 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
N/A |
|
2024-03-04 |
Other |
wheel off of black compressor by MIWE and back glass door of bread |
Found a wheel its still over there.
please reattach |
|
|
Reattached |
|
2024-03-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
complete |
|
2024-03-01 |
Other |
|
the metal table the sheeter is on, needs the leg adjusted. It is wobbly. |
|
|
fixed wobble |
|
2024-03-01 |
Other |
|
we need to trim the legs on the new dunnage rack, the current height to the top of the shelf is 12" total, we need it to be 6" total. I am here today for a bit or back on sunday if you have any questions. |
|
|
trimmed |
|
2024-02-29 |
Other |
Proofer leaking again big puddle in there few inches deep |
\ |
|
|
repaired leaking pipe behind proofer |
|
2024-02-28 |
Other |
Proofer leaking pretty good, puddles in there, and comes back few inches deep fast |
|
|
|
repaired |
|
2024-02-27 |
Plumbing |
|
We started noticing some dripping coming from the ceiling above the prep table. It looks like an insulated pipe might be the culprit. |
|
|
could not verify issue |
|
2024-02-26 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
ok |
|
|
|
2024-02-26 |
|
|
Drain condensation from air compressor tanks of both stationary air compressors |
|
|
drained |
|
2024-02-26 |
Other |
Paper towel dispenser-right hand side bathroom when facing in packaging area. |
paper towel dispenser will not feed out the towels. Has new batteries, but will still not work
Right hand side bathroom in packaging |
|
|
could not find an issue with it |
|
2024-02-26 |
Other |
Replace/ put in place ceiling tiles above food areas |
Ceiling tiles out of place/missing in Delivery hallway and Pastry. Potential contamination situation. This was also in the GMP inspection- PLEASE READ
1. Tile out of place above slicer in delivery hallway above RTE food- MOST IMPORTANT
2. Tiles out of place above oven #1 and Pastry Cooler. |
|
|
replaced |
|
2024-02-25 |
Other |
tile repair |
The tiles under the pot rack in the egg room has several that are chipped. |
|
|
I will be doing tile next month, moved to other tile work order |
|
2024-02-23 |
|
|
Double wide baking rack needs all 4 wheels replaced. They're all sticking whenever there is any weight on the rack |
|
|
lubed wheels |
|
2024-02-22 |
HVAC |
|
Check filters and replace when necessary. Check P traps for condensation and drain as necessary. Check condensor coils. WEEKLY DURING SPRING SUMMER, MONTHLY AFTER FIRST FREEZE |
|
|
replaced |
|
2024-02-21 |
Other |
remove painted wooden shelf from new table |
Please remove red wooden shelf from under new table in new packaging room. Not food safe.
Decide if a new middle support and/or leg would necessary....it may be. |
|
|
removed |
|
2024-02-19 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-02-19 |
Lights |
|
Savory bug light bulb needs replacing. |
|
|
replaced |
