|
2024-07-05 |
Other |
speed rack |
A wheel fell off a speedrack when I pulled it into the freezer. It is currently in the cake studio with tape on it. (I couldn't find our red tags) |
|
|
resecured wheel |
|
2024-07-04 |
Other |
Floor machine will stop moving then have to turn off and on then it will go again, a LOT |
The battery is working fine to my knowledge, this is something else, wher it will not move, it will not auto go....it stops itself mid use and then we gotta turn it off and on to get it to go again. it did this before a ton , it is very difficult to move. its not auto moving correctly, like a while back. Please check |
|
|
Could not verify. Please provide video evidence |
|
2024-07-03 |
Office |
|
can we please have the old speaker removed and the new one put up on the wall? |
|
|
Replaced |
|
2024-07-02 |
Other |
Found red twist knob for pastry hose by LVO on floor |
Please re attach will put on the little shelf in cleaning by the black cabinet |
|
|
replaced |
|
2024-07-02 |
Other |
Floor machine dying a lot mid use, and does not want to go again |
It is very difficult to move the machine, and it is dying a ton more than usual. I had to turn it off and on 4 times to get it from our room thru pastry |
|
|
8:15 Batteries were fully charged |
|
2024-07-01 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-07-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
complete |
|
2024-06-30 |
|
|
No problem, could we get a small hook installed by our hand sink for a brush like the other departments have? |
|
|
changed mind |
|
2024-06-29 |
Other |
Chemical dispenser for floor cleaner going thru very fast |
It has to be way to high of a dilution rate, we go thru a half a jug, in less then 4 hours. please adjust |
|
|
ok |
|
2024-06-28 |
Plumbing |
|
The chiller line keeps freezing. We have tried using agitator an shutting pump off. Neither method is working. Ice is visible on chiller line. It is making water delivery super slow |
|
|
cleaned inline filter |
|
2024-06-27 |
Other |
Santiary Dispener in Bakes first bathroom closest to side entrance by courtyard |
Was on the floor, please re attach, |
|
|
Reattached |
|
2024-06-27 |
|
|
Is there any way we can sand down and re-seal the table that the cookie machine is on? It has many gouges in it and isn't food safe. |
|
|
I have a different solution to this problem, will change table next week |
|
2024-06-26 |
Other |
Please glue the black rubber part on floor machine lid to the machine |
|
|
|
adjusted |
|
2024-06-26 |
Other |
floor machine squeegee, doesn't seem to working well |
|
|
|
dup |
|
2024-06-26 |
Other |
floor machine squeegee, doesn't seem to working well |
|
|
|
dup |
|
2024-06-26 |
Other |
floor machine squeegee, doesn't seem to working well |
|
|
|
dup |
|
2024-06-26 |
Other |
floor machine squeegee, doesn't seem to working well |
|
|
|
dup |
|
2024-06-26 |
Other |
floor machine squeegee, doesn't seem to working well |
|
|
|
adjusted |
|
2024-06-26 |
|
|
Drain condensation from air compressor tanks of both stationary air compressors |
|
|
Drained |
|
2024-06-25 |
|
|
Warehouse door has become unlocked on a few occasions. Seems like the bolt is loose. |
|
|
tightened latching mechanism, greased with wd-40 |
|
2024-06-25 |
Plumbing |
|
Dish pit hose sprung a leak again |
|
|
repaired |
|
2024-06-24 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-06-22 |
Other |
LVO needs to be re-set |
It was stopped in the middle of a cycle and now it will not work. It is off, and should have a sign on it, please reset it. thanks |
|
|
running nominally could not verify issue |
|
2024-06-22 |
HVAC |
|
Check filters and replace when necessary. Check P traps for condensation and drain as necessary. Check condensor coils. WEEKLY DURING SPRING SUMMER, MONTHLY AFTER FIRST FREEZE |
|
|
replaced all roof filters and p traps are good |
|
2024-06-22 |
Other |
slicer blades rubbing on metal guard- Hallway Slicer |
Blades and guards are rubbing together on Delivery Hallway Slicer.
They have brought over 2nd Bakeshop/Employee slicer to use until repair. |
|
|
tightened bolts and sprayed with oil |
|
2024-06-22 |
Other |
Prong stuck again the outlet in Bakeshop by inside viewing window to bread |
|
|
|
removed ground prong. What happened to the plug? Please red tag and put broken plug in maint office thanks! |
|
2024-06-20 |
Other |
pastry water heater |
Water is cold, flame on water heater is out. (I called Jaison and he talked to Tom.) |
|
|
Dion Plumber cleaned out burner, it was dirty |
|
2024-06-18 |
|
|
Vinyl Edge Trim missing egg room/dish |
|
|
replaced edge trim |
|
2024-06-18 |
|
|
The metal vertical/corner moldings on the doorway between the pastry dish room and the egg room need to be reattached. They are sharp and someone almost got cut. The same kind of molding is on the corner from the egg room to the cleaning office. Also needs to be reattached. |
|
|
Removed duplicate |
|
2024-06-18 |
|
|
The vertical molding on the doorway from the packaging room to the locker room needs to be reattached. |
|
|
Removed duplicate |
|
2024-06-17 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
clear |
|
2024-06-13 |
Freezer |
|
Cake freezer fans are making a VERY LOUD noise. |
|
|
Put in extra defrost |
|
2024-06-12 |
Oven |
|
On 12 door Oven; Blow out burners, clean |
|
|
Cleaned |
|
2024-06-12 |
|
|
De-grease, and re-grease bowl lifter lift pole and chain. |
|
|
greased |
|
2024-06-12 |
Other |
wire freezer rack missing support piece for shelf |
A shelf on the small chrome wire rack in the Pastry Freezer is missing one of the black inserts (split sleeves) so the one section of the shelf is unsupported.
It is the second shelf, front left section.
I bumped it and dropped a container of frozen jumble fill :( Be careful! |
|
|
Replaced split sleeve shelf is now secure |
|
2024-06-12 |
Other |
|
middle curtain flaps for CMA have broken / sharp pieces. |
|
|
will replace when needed |
|
2024-06-10 |
Other |
wooden file cabinet in mill room is missing a wheel |
|
|
|
Replaced wheels |
|
2024-06-10 |
Other |
metal bumper in pastry dish is off |
Looks stripped from the wall the screws. I put it between the LVO and the wall there in the small space |
|
20 min |
re mounted into stable stud |
|
2024-06-10 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-06-10 |
Electrical |
|
Bagel divider machine has no power. It's plugged in, no known breaker is flipped, taped button is secure, emergency stop is not engaged |
|
|
Wires came loose in control panel |
|
2024-06-09 |
Other |
Floor scrubber batteries |
Check battery cell levels and flush out cleaner dilution valve |
|
|
Checked and good |
|
2024-06-07 |
Other |
Hand trucks / Dollies |
Hand truck plate broke. Need to put a new one on. The new piece is hanging off handle of broken handtruck in delivery dock bay. |
|
|
replaced broken parts |
|
2024-06-07 |
Other |
Bug light |
Bug light is acting as a strobe light. (Flashing a little too much). Thanks! |
|
|
reseated bulb |
|
2024-06-04 |
Other |
knocked flap/flute thing into the pipe above MIWE |
Told Bread crew, and showed him. It is the pipe by the tall ladder there, i was dusting it and it went right into the pipe, and i can not reach anything. |
|
|
Found flap thing and ordering new |
|
2024-06-03 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-06-03 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
complete |
|
2024-06-03 |
|
|
Rung on the drying rack is corroded. It's tagged and still in the dish room. Is there a replacement in the warehouse? |
|
|
ordered new stainless rack |
|
2024-06-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
All clear |
|
2024-06-01 |
|
|
Speed rack has a broken rung. Tagged and in egg room |
|
|
repaired |
|
2024-05-31 |
Other |
Equipment Maintenance |
Pastry's blow torch, the one marked 'M' doesn't spark when the trigger is pulled, so gas comes out but no flame. The torch is currently red tagged on the Pastry Manager's desk in the Manager's Office. We tried using a hand lighter to ignite it, but the majority of the time the gas coming out was forceful enough to just blow the lighter out before it could ignite the torch. |
|
|
repaired |
