|
2025-01-02 |
|
|
Bread racks “boxes”, casters for E R
Wheels for P , K |
|
|
changed wheels as needed |
|
2025-01-02 |
|
|
double wide baking rack has stuck wheels- red tagged and in the red (tile) room near packaging.
Thanks! |
|
|
could not locate - tom must have fixed it |
|
2025-01-01 |
Other |
|
shut off water, drain about 15 gallons of water then check tank pressure. Should be at 65 lbs. |
|
|
63 psi |
|
2025-01-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
checked all gas appliances for leaks |
|
2025-01-01 |
Other |
Oil gun |
Hose is falling out need to be attached on the inside by zip tie thanx |
|
|
repaired |
|
2024-12-31 |
|
|
We would like to install a door closer on the warehouse, to prevent the door from slamming shut, and to make sure it latches behind people. ZSN has some we might be able to use. |
|
|
Installed |
|
2024-12-30 |
Plumbing |
|
Left hand toilet in packaging won't flush |
|
|
repaired |
|
2024-12-30 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-12-29 |
|
|
All bread "Double-wide" Baking racks need wheel work, lubrication or casters replaced. |
|
|
lubed and changed where needed |
|
2024-12-28 |
Other |
|
we changed the batteries recently in our paper towel dispenser. Now it lets out 3-5 feet at a time. Let us know if we need to get another or what is going on, since it feels like we are wasting a lot of paper towels. |
|
|
unable to repair. marked for replacement |
|
2024-12-27 |
|
|
|
|
|
Inspected and Passed |
|
2024-12-26 |
|
|
Bread racks A E R T I all need either new wheels or casters for wheels |
|
|
Consolidated work orders |
|
2024-12-26 |
|
|
Drain condensation from air compressor tanks of both stationary air compressors |
|
|
Drained |
|
2024-12-23 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-12-23 |
Other |
|
can we please get more grippy mats under the legs of the table in front of the consult room window? It is sliding again pretty bad |
|
|
complete |
|
2024-12-22 |
HVAC |
|
Check filters and replace (Monthly). Check P traps for condensation and drain as necessary. Check condensor coils and clean as needed every month. |
|
|
Replaced all roof top unit filters |
|
2024-12-22 |
Other |
40 quart whisk |
Broken wire- red tagged on pastry managers desk. |
|
|
replaced |
|
2024-12-21 |
|
|
The hot water handle won't completely shut off in the dish room for the three compartment sink. Thanks! |
|
|
replaced both hot and cold rubber washers |
|
2024-12-20 |
Other |
Equipment Maintenance |
Brownie cutter is making the first cut in both directions very late, causing the first brownie to be extra long in that dimension and the last to be extra short. Brownies in the middle seem to be cut about normal. |
|
|
adjusted guides for brownie bites, I could not eliminate the top being cut short. All other bites should be more or less the same except the top row, which are very very thin. |
|
2024-12-20 |
Other |
water heater |
The hot water was out again tonight. The display code on the water heater was reading 64 again, which is some malfunction with the electronics box. I did what Jaison had me do the other night by unplugging / replugging in the box, which reset this and fixed the issue. Seems like an ongoing issue and something needs to be repaired / replaced. Thanks! |
|
|
coming out tomorrow |
|
2024-12-20 |
Other |
40 quart whisk |
Wire broke when using. Red tagged and in pastry managers desk. |
|
|
repaired! :) |
|
2024-12-19 |
Other |
Broken speed rack |
Broken support at bottom of speed rack. |
|
|
Repaired |
|
2024-12-16 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-12-13 |
Other |
freezer truck 1- ground truck |
Truck is displaying ERROR CODE: AL 53- Ni Cad Battery pack failure. |
|
|
reset |
|
2024-12-13 |
|
|
Bagel machine belt slows down considerably when a bagel enters bagel shaping part of the machine. Belt runs fine with no bagels on the belt. Might be a motor issue, or the large rollers that move the belt need to be cleaned. i will make a short video to upload, otherwise it will need to be witnessed during bagels ETA 6pm. |
|
|
tightened belt. It may or may not need to be tightened more. |
|
2024-12-12 |
Oven |
|
On 12 door Oven; Blow out burners, clean |
|
|
Cleaned |
|
2024-12-12 |
|
|
De-grease, and re-grease bowl lifter lift pole and chain. |
|
|
greased |
|
2024-12-12 |
Plumbing |
|
Our handsink is having points where there is no water at all coming out when we push the pedal. |
|
|
repaired |
|
2024-12-12 |
Other |
Delivery room fan switch cord broken |
Switch cord on lower wall mounted cooling fan in delivery broke off the unit tonight. Can't switch it off. |
|
|
dup |
|
2024-12-12 |
Other |
Delivery room fan switch cord broken |
Switch cord on lower wall mounted cooling fan in delivery broke off the unit tonight. Can't switch it off. |
|
|
repaired |
|
2024-12-10 |
Freezer |
|
the freezer is coating everything under it in ice. We are unable to get some of our 5 gallon buckets out because the ice on top of them are too thick. I used the bucket opener to free it, but can't get it from under the shelf above it. |
|
|
Defrosted several cycles, drain frozen |
|
2024-12-09 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-12-09 |
Other |
Floor scrubber batteries |
Check battery cell levels and flush out cleaner dilution valve |
|
|
good |
|
2024-12-09 |
Other |
Bun Slicer |
Power button broke off while Gavin was slicing, Mj tried to get it to run but apparently when powered on, the power switch on the slicer sparked so they immediately unplugged it.
I did not experience this firsthand. |
|
|
replaced switch |
|
2024-12-09 |
|
|
metal "plank" used to sweep top deck of MIWI oven is coming apart. it is held together by only two screws. |
|
|
repaired |
|
2024-12-07 |
|
|
drinking fountain button broke off |
|
|
repaired |
|
2024-12-05 |
Other |
Drain by bagel kettle |
There is a gap in the grate, and because we are working there, it can be a safety issue when we are stepping around it. |
|
|
put drain covers back in proper place |
|
2024-12-04 |
Other |
Very sharp metal piece- by flow wrapper |
Extremely sharp piece that is a hazard. It is fastened to the wall, under drywall. |
|
|
Removed sharp piece |
|
2024-12-03 |
|
|
Scaling table in the mix area is falling apart, needs to be put back together and secured. |
|
|
repaired |
|
2024-12-02 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
|
2024-12-02 |
Other |
|
Metal cover for Miwe air conditioner bolts stripped |
|
|
repaired |
|
2024-12-01 |
Plumbing |
|
Using Gas Sniffer check all gas operated for leaks or potential |
|
|
Checked and good |
|
2024-12-01 |
Other |
|
the top shelf of the dish cart needs to be stabilized. it is slanting and while still in use capacity is limited in its current state |
|
|
fixed |
|
2024-11-30 |
Other |
Rack wheels |
One of the wheels is broken. |
|
|
repaired wheel |
|
2024-11-29 |
Other |
Freezer truck 1 |
Freezer truck alarm code for truck 1 was - AL 53: Ni Cad - Battery pack failure. |
|
|
Has not coded since. I will continue to monitor |
|
2024-11-27 |
Other |
40 Quart whisk |
One of the wire pieces broke. Can we please have this one cut off?
It is in the production office on the pastry desk. |
|
|
Repaired |
|
2024-11-26 |
Freezer |
|
the freezer seems to be thawing deeply and making everything in the back covered with a thick layer of ice and now slippery ice on the floor. |
|
|
put it through 2 extra defrosts |
|
2024-11-26 |
|
|
Drain condensation from air compressor tanks of both stationary air compressors |
|
|
Drained |
|
2024-11-26 |
Mixer |
|
A time has come loose on one of the 140qt whisks. It is red tagged |
|
|
Repaired |
|
2024-11-25 |
Walk-In |
|
Vacuum Water from under compressors to prevent water leaking into delivery room. |
|
|
ok |
