LVO
Location:
Pastry
Work Orders
Date requested |
Type | Problem | Cost | Time spent | Status | |
|---|---|---|---|---|---|---|
| 2026-05-28 | Other | WELDING | The bowl washing rack lost a wire rung. It is on the pastry desk in the production managers office. | |||
| 2026-05-27 | Plumbing | Delime if needed | ok | |||
| 2026-05-08 | Plumbing | We've needed to refill the LVO several times due to not enough water. There are no obvious leaks or draining issues so not sure what's going on | being repaired next week | |||
| 2026-05-05 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | Applied grease into the insert | |||
| 2026-05-01 | Plumbing | Delime if needed | ok | |||
| 2026-05-01 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | done! | |||
| 2026-04-20 | The float sensor that tells the LVO to stop filling got stuck again. | cleaned and functional | ||||
| 2026-04-02 | Two screws are missing and only two holds the mid section of the lvo door. | repaired | ||||
| 2026-03-29 | Soap not being dispensed into LVO during cycle. Pump can be primed without issue, blockage likely in plastic lines or buildup at exit spout. | replaced vacuum tube and clear tube. working perfectly now | ||||
| 2026-03-27 | Plumbing | Delime if needed | ok | |||
| 2026-03-23 | LVO heater blower shuts off after running for a few seconds. Does not reach 150 degrees. Rinse temp unaffected | repaired. issues were: pilot gas pressure too low, dirty electrode, bad flame sensor, water in burner, hole in casing. | ||||
| 2026-03-03 | Other | LVO soap line may be restricted/ clogged | Inconsistent high cleaning verification readings on items coming out of LVO. Russ discovered that the soap output line (after the pump machine) seems to have some build up that may be causing inconsistent soap into the machine. Can you inspect and see if you agree? Picture attached | repaired | ||
| 2026-02-27 | Plumbing | Delime if needed | ok | |||
| 2026-02-27 | Plumbing | Delime if needed | duplicate | |||
| 2026-02-05 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | greased | |||
| 2026-02-01 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | greased | |||
| 2026-01-27 | Plumbing | Delime if needed | Ok | |||
| 2026-01-11 | Electrical | LVO starts up and acts like it's filled, when it's not. Noticed a burning smell from it when it was on. | repaired. loosened hinge on float switch | |||
| 2026-01-11 | Plumbing | water leaking from burner flange, video sent to Ben | in other work order | |||
| 2025-12-27 | Plumbing | Delime if needed | ok | |||
| 2025-12-09 | Other | WELDING | All of the welds attached to the pipe under the LVO's floor have broken, along with a couple of spots on the pipe running up the wall. | Andy graciously repaired our LVO | ||
| 2025-12-02 | Other | LVO | A small piece broke off from inside the handle housing. The handle still opens and latches properly. | assessed and ok | ||
| 2025-11-27 | Plumbing | Delime if needed | ok | |||
| 2025-11-26 | Other | Nozzle for hose came went down drain | replaced | |||
| 2025-11-05 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | lubed | |||
| 2025-11-01 | Other | Add 2 pumps to each of the inserts on the pump motor and impeller. | lubed | |||
| 2025-10-27 | Plumbing | Delime if needed | ok | |||
| 2025-10-15 | Other | Panel cover on back of LVO needs re-securing. | The back panel cover on the LVO popped open at the top during a cycle. We turned off power to the machine and at the power box. We found one of the screws but could not find the other even after searching in drain. Re-secured the top left, but need top right secured. Currently bungeed close to keep secure. | Resecured | ||
| 2025-09-27 | Delime if needed and check water quality in Rack washer. | ok | ||||
| 2025-09-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | ok | ||||
| 2025-08-27 | Delime if needed and check water quality in Rack washer. | ok | ||||
| 2025-08-25 | Plumbing | Float switch on LVO doesn't consistently engage. We had an issue today where we had low water and added more but then it wouldn't stop filling- and most odd, it still kept filling even after we turned the machine off. We had to turn the water off to the machine. Jaison checked out the float switch and wires and he did get it to stop and it *seems* to be running okay at this time. But we're not 100% it's fully fixed. | installed plate blocking water | |||
| 2025-08-17 | Plumbing | rinse cycle still not consistently getting up to temp | duplicate | |||
| 2025-08-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | ok | ||||
| 2025-08-02 | The rinse temp is low- around 80. Thanks! | repaired | ||||
| 2025-07-27 | Delime if needed and check water quality in Rack washer. | Delimed | ||||
| 2025-07-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | Delimed | ||||
| 2025-07-05 | The handle of the LVO is loose and missing one screw. | tightened, it is secure | ||||
| 2025-06-27 | Delime if needed and check water quality in Rack washer. | ok till next week | ||||
| 2025-06-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | cleaned | ||||
| 2025-05-27 | Delime if needed and check water quality in Rack washer. | Delimed | ||||
| 2025-05-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | Delimed | ||||
| 2025-04-29 | It looks like the welding broke in the LVO where the little trays are held! | I will make a note next time our stainless welder comes I will have him weld it. Not a huge concern at this point. Thank you | ||||
| 2025-04-27 | Delime if needed and check water quality in Rack washer. | ok | ||||
| 2025-04-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | delimed | ||||
| 2025-03-27 | Delime if needed and check water quality in Rack washer. | ok | ||||
| 2025-03-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | Delimed | ||||
| 2025-02-27 | Delime if needed and check water quality in Rack washer. | ok | ||||
| 2025-02-11 | Delime with 1 gallon Eco Lyme every 3 weeks and wash down sidewall | Delimed | ||||
| 2025-01-27 | Delime if needed and check water quality in Rack washer. | Delimed |