User login

Hobart Dish Machine

Location: 
BAKE! Front Classroom

Model Number AM-14C
Serial Number 27-173-155
Volts 200-230
Hz 60
Phase 3
Amps 23.9


Work Orders

New work order

Date requestedsort icon Type Problem Cost Time spent Status
2020-04-13 Very low priority: the Bake dish machine is not holding water. Thanks! Ordered O-ring and replaced
2020-03-12 We would like to install a knife block for clean knives in our dish-room. We probably need to install it into the concrete brick between the dish machine and the drying shelf. This will make our dish-room safer. No rush. installed knive block
2020-03-08 Bake's dish machine is not keeping up to temp during busy hours. Has dropped below 115 and takes a lot of time to come back up to temp. Complete
2019-11-24 Other One of the screws holding up the left counter for the dish machine has come loose, and the plastic plug it fit into in the wall is cracked in half. Could use a replacement to keep water from pooling on that side. Very low priority. repaired
2019-11-14 HVAC The fan/vent above the dish machine makes an intermittent loud whistling noise, audible outside the dish room. It will occasionally improve if you turn the fan off and on again, but not always. I have a video of the sound if you need it. fan is operating normally, I checked motor mounts and no vibration. Often ice and snow form on the cap which could cause some wierd sounds
2019-07-16 dish machine not cleaning dishes properly Not urgent. Our Hobart dish machine is not cleaning dishes off as well as it used to, especially dishes that are in the corners of the machine. Not sure if something's blocked up somewhere or the rinse arms aren't spinning correctly, but we'd appreciate someone coming to look at it. Thanks! was not getting sanitizer, replaced motor
2019-02-08 Tiny pin hole leak in the hose that feeds the sanitizer into the machine. It is only noticeable when the machine is going through the sanitizing cycle, or it is filling. The only reason we noticed it was that its bleach and when it sits on top of the machine in high concentrations for extended periods it starts to corrode the metal. We tried putting a piece of duct tape over it, but it just leaks out from under the tape now instead of spraying a tiny stream in one direction. Thanks! Repaired leaking line
2019-02-06 The dish machine has a tiny leak in a hose (seems like the hose that brings in the bleach sanitizer). The machine is still useable, not showering everywhere like Sunday, but probably needs to be fixed at some point. unable to find leak, maybe if you see it put a piece of tape on it. Thanks
2019-02-03 Plumbing The hose attached to the top of the dish machine has come off and sprays water everywhere when we try to fill it. Help! replaced copper pipe
2018-09-21 Other dishwasher needs a new bucket of sanitizer This is not a maintenance issues
2018-07-25 Plumbing Dish machine is not pulling sanitizer
2018-07-15 Plumbing our water is back to not heating properly - still warm, but not hot.
2018-07-12 Plumbing our water isn't heating up properly - pilot light may need to be relit - high priority complete
2018-06-13 Other dishwasher not pulling sanitizer Our dishwasher isn't using the sanitizer, and smells like hot garbage juice. Completed
2018-05-31 Overflowing Drain in the 3 Compartment Sink The drain on the 3 compartment sink is overflowing when draining (hasn't done this in awhile). Low priority. Completed
2018-03-25 Other Dish machine Hobart Dish machine is not distributing soap, also not distributing sanitizer. Temp is off on sanitize program seems to stay at 118. 20 mins complete
2018-03-03 Plumbing The enzyme bucket is not working 10mins complete
2018-01-21 Other Burning smell coming from dish machine 15 mins complete
2018-01-21 Other Dishroom sink enzyme bucket empty & battery low on dispenser - please replace, thank you! 10mins complete
2017-12-16 Dish machine The BAKE! dish machine is the burning smell and smoke again again from plastic melting on to the heating element in the tank. 30 Complete
2017-12-12 The sprayer on the dish machine in BAKE! is clogging and not spraying well. The sanitizer control box on the left is also leaking and forming residue on one of the hoses. 30mins complete
2017-11-21 Dish machine Leaking from rusted spout on top 20 mins complete
2017-11-11 Other Dish machine Dish machine smelling hot, same smell as when the coils needed cleaning. 30mins complete
2017-11-02 Other The Hobart dish machine in BAKE! is smoking and smells like burning plastic when in use. We de-scaled the machine but it did not seem to fix the problem. 30mins complete
2017-09-28 The sanitizer and control box above the left side of the hobart dish machine is dripping something on to the stainless steel surface causing discoloration and corrosion. The machine also smells like it is burning, fumes are coming from the tank. 30 min Complete
2017-09-14 Other The hobart dish machine in BAKE! is leaking badly in the back corner. The pooling of water is causing mold and flies that the students are starting to notice. The drain on the machine is also constantly leaking, may need new seals. 20 mins complete
2017-05-27 No sanitizer!! .5 Complete
2017-05-07 Plumbing Dish machine is squirting sanitizer in various directions 1 Complete
2017-04-26 The small black hose inside of the sanitizer pump broke loose from the orange twist tie on the left. It was reattached, but needs a new twist tie to hold the hose in place. 20 min complete
2017-04-01 The BAKE! dish machine is developing a heavy brown film inside that smells like paint 1 Complete
2017-03-17 The Hobart dish machine is spraying water from the door as it is running. 65. 1 Complete
2017-03-01 The washer hose head on the Hobart dish machine needs to be replaced 55.00 complete
2017-02-18 The sprayer head on the BAKE! dish machine is spraying sideways, might need to be replaced. Complete
2017-02-18 The dish machine in BAKE! is smoking and smells like burning plastic. 5 Complete
2017-01-13 Dish machine isn't getting hot water. It's at 78*F. Complete
2016-12-22 We think the detergent tube in the Hobart has a kink in it. complete
2016-12-20 Other Hobart Dish machine Machine is smelling HOT. Complete
2016-12-03 Other Dishwasher Our dish machine is not getting up to the right sanitizing levels. Also, it smells a little like burning. Perhaps there is a relationship? 20 Complete
2016-09-18 Plumbing The sprayer head on the hose for the Hobart dish machine is wearing out and not spraying well. We have cleaned it out a few times now but it is getting weaker, needs to be replaced. complete
2016-04-08 Plumbing Sanitizer readings are low Sanitizer level in bucket very low. Started a new bucket and primed the sanitizer
2016-02-11 Hobart dish machine is not feeding soap completed.new control installed
2016-01-29 Plumbing The soap dispenser to the Hobart dish machine is not supplying enough soap to the wash. complete
2015-12-14 broken/stripped out chlorine fitting shooting water all over during rinse cycle completed
2015-08-17 Plumbing water hose on the dish machine is broken and leaking badly. Replaced plastic line with copper line to stop the regular leaks.
2015-07-26 Plumbing Emilia reported a leak and water puddling under the Hobart dish machine zero Cleaned the dried crud out of the water trough on the backside of the dish machine
2015-06-20 Plumbing Bake Hobart dish machine plastic water line has pinhole leak zero Repaired line, repositioned so that the angle at the fitting is not so dramatic
2015-06-10 Plumbing There is a leak in the back if the machine that is running down to the floor causing the floor tiles to come up. COMPLETED.
2015-05-19 Other flow of soap in Hobart Dishwasher Appears as though soap flow may not be pressurized enough resulting in a lower amount of soap in the dishwasher. COMPLETED.
2015-04-01 Other Hose nozzle repair The rubber/plastic nozzle on the Hobart dish machine hose is spraying sideways, getting clogged, and is not sealing on to the hose properly. Rubber grommet is no longer staying sealed to the hose. completed.

Maintenance Record

New maintenance record