Douglas-Bucket Washer
Location:
Bread
Work Orders
Date requested |
Type | Problem | Cost | Time spent | Status | |
|---|---|---|---|---|---|---|
| 2023-05-02 | Was pressure at 20/30 | wash temp 30 ok | ||||
| 2023-05-01 | Delime with Eco Lyme. ! quart for both tanks, Clean jets, screens and sidewalls | delimed | ||||
| 2023-04-30 | Wash Pressure running at 22/30 | ok | ||||
| 2023-04-25 | Please, reattach metal sticking off the door inside | complete | ||||
| 2023-04-24 | not sure | |||||
| 2023-04-05 | Sprayer arms in Douglas bucket wash are clogged on outer holes. This is in both top and bottom sprayer arms. | cleaned out | ||||
| 2023-04-02 | Plumbing | Douglas Washer soap not working properly. DEMA Machine does state "Wash Trigger" but no water flow to soap dispenser during wash cycle. Therefore, cannot properly remove allergens- ATP swab verify issue. Sign on machine for folks to manually prime soap until it can be fixed. Manual soap prime does work. | working according to specs. | |||
| 2022-08-29 | Other | Douglas machine rinse not getting up to temp (only reaches 140 degrees max) | Reading 190 degrees at 1:31 pm. | |||
| 2022-08-01 | Plumbing | Hot water is constantly spraying from above and below in the Douglas unless the water line is turned off. Very dangerous. | Complete | |||
| 2022-07-30 | Plumbing | The Douglas is constantly running water though to a lesser degree than when we called about it. The water is still dripping from the top too and is very hot. | could not verify, possible valve stuck | |||
| 2022-07-24 | Plumbing | Douglas rise pressure is too high. Pressure release valve is causing a lot of noise and the pipe above is shaking. | Complete | |||
| 2022-07-20 | Douglas rinse temp is below 150 (should be 180 or above). Flame is not staying lit. | Complete | ||||
| 2022-07-16 | Plumbing | The Douglas makes a weird noise sometimes during the rinse cycle. | Complete | |||
| 2022-07-12 | Bottom jets are not working well. Maybe clogged. | CLEANED OUT | ||||
| 2022-02-15 | Wash pressure on Douglas is low (<30) | please drain dirty water and empty screens | ||||
| 2022-02-04 | Other | Douglas machine | Pipe leaking from top down onto everything. | cleaned back flow preventer | ||
| 2022-01-18 | Electrical | Douglas was temp at 140. Pilot light is not on. | operating properly | |||
| 2021-09-20 | Electrical | Wall mounted fan not working. I tried a different socket with no change | Complete | |||
| 2021-09-09 | Plumbing | Right side leaking from soap hose attachment while running | repaired | |||
| 2021-08-21 | Small leak in hose of pressure sprayer on bucket wash machine. | Could not verify | ||||
| 2021-08-12 | Can you check the wash gauge to see if it is reading right? It feels like it is running hot but the temperature is below what's needed to for the dish log. | replaced thermostat, also found pressure at 20 lbs. I drained and put clean water in 35 lbs. | ||||
| 2021-07-28 | Bread- bucket machine not getting up to temp. Seems to be trying to relight, but not sure it’s successful. | Complete | ||||
| 2021-06-12 | Electrical | The temp gauge on the bucket machine for the wash cycle isn’t reaching the right temp. This happened a few weeks ago too. Gauge just stays at the far left | Complete | |||
| 2021-06-02 | Other | Wash temperature running under temp | as I have stated, numerous times this machine is quite old, it may be the gauge off a little or just wear on the pump or even dirty water will cause it to read 30 lbs. of pressure | |||
| 2021-05-24 | Wash temperature reading zero constantly. Water feels cold. | Hot water was not working | ||||
| 2021-05-18 | Electrical | Douglas wash pressure at 30/35 | See notes | |||
| 2021-05-08 | Plumbing | The Douglas seems to be adding additional water for each cycle, filling up even above the bottom wash bar after a few cycles. | 5hrs | Complete | ||
| 2021-04-05 | The Douglas is missing its rinse gauge off the top of the machine. Need a new rinse gauge installed. | it was ordered last week | ||||
| 2021-03-25 | Plumbing | Douglas is leaking from the rinse pressure gauge | Complete | |||
| 2021-02-11 | Douglas leek from top while running left of top pressure gauge. | Complete | ||||
| 2021-01-05 | Plumbing | The Douglas is leaking pretty profusely from right by the rinse pressure gauge. | replaced gauge | |||
| 2020-12-19 | Plumbing | The Douglas washes the bucket for between 10 and 30 seconds and shuts off due to a Er06 error | Complete | |||
| 2020-12-16 | Bucket machine won’t run. E06 error keeps flashing | running fine | ||||
| 2020-11-30 | Other | Loose door latch | The door latch keeps coming loose which makes the Douglas error code. | tightened | ||
| 2020-10-14 | Lower spindle tilted, making ugly banging noise when running | replaced hub assy. | ordered new bearings | |||
| 2020-10-10 | Other | Dishwasher & Bucket Wash | Douglas Bucket Wash machine is not meeting the required wash temp and wash pressure. | wash pressure 35 psi and wash temp. 150 plus | ||
| 2020-09-20 | Other | Douglas | The Douglas upper right door hinge is loose. | tightened hinge | ||
| 2020-09-12 | Other | The metal grate that keeps buckets from flipping over in the bucket machine is falling apart. Pretty much unusable at this point and we really need it | Complete | |||
| 2020-08-19 | A couple of the plastic feet on the rack for the Douglas Bucket wash machine are loose/fallen off. I pulled out some parts from the bottom of the machine and put them in a container, on the Bread managers' desk. Please replace. | Complete | ||||
| 2020-08-10 | Bread - bucket washer - top hinge on door snapped. Unable to use currently. | temporary hinge will order new | ||||
| 2020-07-12 | Plumbing | Douglas washer has leak above machine during rinse cycle. Pressure remains steady. | duplicate | |||
| 2020-07-11 | Plumbing | The Douglas is leaking pretty badly during the rinse cycle from a pipe at the very top of it that looks like it has a metal cap. | duplicate | |||
| 2020-07-10 | This keeps showing a low Wash Pressure. | replaced back flo preventer, cleaned pump, wash pressure 40 lbs. | ||||
| 2020-06-13 | the handle for the catch screen (filter at bottom of Douglas bucket washer) is detached on one side, and the screw looks stripped on the other side. | repaired |